data brief for further information contact your local stmicroelectronics sales office. july 2009 doc id 15458 rev 3 1/9 9 STI5189 low-cost qpsk demodulator and mpeg2 decoder for set-top box applications features dvb-s compliant qpsk demodulation and diseqc ? controller mpeg2 mp@ml video decoding audio decoding (mpeg1, 2, mp3, dolby digital 5.1) linux and os21 compatible st40 applications cpu (350 mhz) 16-bit sdr/ddr1 compatible local memory interface multi-stream, dvr capable, transport stream processing extensive connectivity (usb 2.0 host/ulpi, ethernet mac mii/rmii, dvb-ci) external memory interface supporting nor, nand and serial flash advanced security features, compatible with the latest ca requirements satellite stbs can be produced with very small bom and two-layer pcbs active and passive low power modes integrated voltage regulator two package options: pbga 23x23 and lfbga 15x15 description the STI5189 integrates in a single ic, qpsk demodulation, fec, multi-stream transport demultiplexing, an applications cpu, audio/video decode, video processing, graphics and display, advanced security, stb peripherals, audio/video dacs, digital audio/video outputs, usb 2.0 host controller/ulpi and an ethernet mac mii/rmii interface. jtag stb peripherals i/o digital video sd in/out resets analog out clocks modes pcm i/o s/pdif out external interrupts clock gen system serv peripherals ssc uart gpio pwm infrared smartcard connectivity transport security pti ts merger lcmpeg video planes graphic planes cursor plane main vdp deinterlacer capture dvos denc teletext dacs vtg analog video sd out audio i/o display video i/o transport streams parallel/serial in/out audio decoder video decoder emi spi lmi system interfaces aux vdp cpu/fpu mmu interrupts i cache d cache timer st40 350mhz debug stbus pcm players s/pdif player dacs fdma blitter display flash, sflash nor, nand usb ethernet demodulator dvb-s iq in transport streams sdram/ddr serial flash memory ilc www.st.com
introduction STI5189 2/9 doc id 15458 rev 3 1 introduction the STI5189 uses state of the art process technology to provide an ultra low cost, full featured, sd set-top box soc. it is a highly integrated solution combining qpsk (quadrature phase shift keying) demodulation, audio/video decoding and applications processing into a single chip, suitable for mpeg2 based satellite networks worldwide. the STI5189 provides a solution for operators to specify a range of low cost sd stbs including low cost zappers, interactive stbs and dvr-capable stbs, with content delivery using broadcast or broadband networks, or both (hybrid stbs). the STI5189 is optimized for secure pay-tv applications with integrated dvb, des, multi2 and icam descramblers and smartcard interfaces. it also has advanced security features normally found in mid-to-high end devices to further safeguard operator and content investment. the STI5189 offers enhancements in performance, features and integration to current users of st?s mpeg2 sd family of audio/video decoders and qpsk demodulators, whilst reducing cost and time-to-market for the next generation of deployments. few external components are required to realize a complete stb solution, resulting in very low bom cost. features benefits combines a configurable dvb-s qpsk demodulator with stb decoding and display functions this highly integrated soc helps to reduce board area and manufacturing cost, allowing low-cost, small size stbs to be designed for dvb-s networks st40-300 applications cpu @350mhz, 32k i cache, 32k d cache up to 580 dmips superscalar performance from a single cpu core, using standard tools and operating systems (linux, os21) stmicroelectronics' delta video decoding system with blitter display allows dual sd decoding of mpeg2 video with pip capability integrated usb 2.0 host, ethernet mac with mii/rmii, enables connectivity to hdd for pvr systems and to ethernet networks for ip tv and hybrid/ip stbs low power process, design and architecture low operating power consumption (<1w). best in class, low power standby mode (0.1w). fast resume from standby. available in 15x15 package with ballout optimized for 2-layer pcbs reduced board manufacturing costs and board size support for serial flash including secure boot. allows low cost bom, and safeguards boot code integrity
STI5189 introduction doc id 15458 rev 3 3/9 1.1 features summary the STI5189 has the following features: embedded qpsk demodulator ? fast channel acquisition ? compatible with direct conversion tuners ? digital carrier and timing recovery loops ? dvb-s decoding ? up to 60 msps operation ? automatic spectral inversion ambiguity resolution ? digital cancellation of a/d offset ? digital nyquist root filter high performance cpu for applications, middleware, drivers, audio decoding and network protocols ? st40-300, dual-issue, applications cpu ? fpu, mmu, 32k instruction, 32k data, 2-way, set-associative caches ? supports os21 and linux operating systems ? target speed > 350 mhz delivering >580dmips single, 16-bit wide, unified local memory interface ? supports both sdr sdram up to 166 mhz and ddr1 sdram up to 200 mhz mpeg2 mp@ml video decoder, dual sd decoding/pip capable audio sub-system ? mpeg-1 layers i/ii decoding ? mp3 decoding ? dolby digital 5.1 decoding and down mix to stereo/pro-logic ? concurrent decoding of audio description ? optional feature: btsc stereo encoding ? pcm mixing with sample rate conversion ? simultaneous audio decode and output of dolby streams on s/pdif iec60958/iec61937 digital audio output interface ? integrated stereo audio dac system programmable external memory interface ? four separately configurable banks, 8/16-bit wide ? sram, peripheral, nor flash, nand flash, burst mode flash support ? boot from nor or nand flash ? support for dvb-ci module host interface interface to, and boot from, serial flash via high speed spi interface ? dual output read support graphics/display processing ? high performance 2-d graphics blitter accelerator and display compositor, link list control
introduction STI5189 4/9 doc id 15458 rev 3 ? multi-plane video/graphics composition with alpha blending, typical four-plane use case (background color + still plane + video plane + osd plane), and integrated tile ram bandwidth saver for enhanced performance ? high quality horizontal and vertical reformatting and resizing, with sample rate conversion/filtering for video and graphics ? 8 bpp clut and 16 bpp true color graphics formats supported ? advanced anti-flicker filtering ? de-interlacing sd to 480p/576p for hdmi output display output ? pal/ntsc/secam encoder ? encoding of cgms, teletext, wss, vps, closed caption ? macrovision tm 7.1d copy protection ? four 10-bit video dacs, outputting rgb/cvbs/yc analog video signals ? high drive-capability on one of the video dacs for cvbs output without buffering ? 8-bit digital video output (dvo), compliant with itu-r bt 601/656 formats ? 54 mhz output data rate on dvo supporting 480p/576p output over 8 bits dvr capable transport sub-system ? ts reception from internal qpsk demodulator ? external ts interface for a second stream input from external tuner/demodulator ? dual internal ts from memory for network/ip stream input and dvr playback ? ts output for routing to dvb-ci module ? dvb-compliant, triple-stream transport de-multiplexing dvb, des, multi2 descrambling dvr supported with hdd attachment via eide (pio mode) or usb 2.0 multi-channel flexible dma controller connectivity ? 10/100 ethernet mac with mii/rmii interface to external phy ? usb 2.0 host controller with ulpi interface to external phy on-chip stb peripherals ? two smartcard interfaces with integrated clock generation ? four uarts with tx and rx fifos ? three sscs for i2c/spi master/slave interfaces, one of which can be dedicated for tuner control with minimum tuner disturbance ? five 8-bit gpio banks with alternate functions ? infrared transmitter/receiver ?pwm ? cec line controller system services ? all clocks generated from a single external crystal ? integrated dco for clock recovery ? low power/rtc/watchdog controller ? jtag/tap interface ?
STI5189 introduction doc id 15458 rev 3 5/9 advanced security ? secure control words ? code authentication ? jtag interface locking ? dvr copy protection on chip 1v (nominal) voltage regulator two package options ? 23 mm x 23 mm. full specification ? 15 mm x 15 mm. no emi. boot from serial flash only 1.2 package options the STI5189 is available in two package options, 15 mm x 15 mm lfbga, 0.8 mm pitch and 23 mm x 23 mm pbga, 0.8 mm pitch. both package types are compatible with the design of two-layer pcbs. 15 mm x 15 mm pbga, 0.8 mm pitch this is the main stream, low cost option which does not include the emi interface. both ethernet and usb 2.0 interfaces are still available. for this option the flash used must be serial nor flash attached to the high speed spi interface. 23 mm x 23 mm pbga, 0.8 mm pitch this option should be selected if a full specification device is required, which includes the emi. any flash type (serial nor, parallel nor, nand) can be used with this package. the following features are available with this package option: all the features as in the bga15 mm x 15 mm package dvb-ci support nand flash storage emi interfaces available, secure boot from any flash (serial, nand or nor) hdd attachment via eide with this package, dvb-ci and ethernet are mutually exclusive options. table 1. comparison table features bga 15mmx15mm (low-cost option) bga 23 mm x 23 mm (full specification option) external memory interface no emi, secure boot from serial flash emi supporting serial flash, parallel nor, nand, secure boot from any connectivity usb 2.0, ethernet (mii/rmii) usb 2.0, ethernet (mii/rmii), atapi hdd dvb-ci support no yes transport streams parallel/serial ts in, ts out (1) parallel/serial ts in, ts out (2)
introduction STI5189 6/9 doc id 15458 rev 3 1.3 target applications the following diagrams show typical applications of the STI5189. the first two use the 15 mm x 15 mm package version. the other application use the 23 mm x 23 mm package version. figure 1. mpeg2 broadcast satellite stb (basic zapper) smartcard supported two two hdmi support through dvo yes yes gpio banks/uarts 5/4 5/4 two layers pcb design optimized yes yes power supplies optimize some analog power supplies separate analog power supplies applications ? very compact stb, basic zapper, basic dvr with hdd on usb. ? secure application with only one smartcard consider this option if any of the following required: dvb-ci, hdd attached through eide, nand flash storage 1. muxed with ethernet pins. 2. muxed with ethernet pins. table 1. comparison table (continued) features bga 15mmx15mm (low-cost option) bga 23 mm x 23 mm (full specification option) STI5189 iq in vcr satellite flash ir tx/rx sdr or cvbs smartcard tuner lfbga 15 x 15 ddr hs-spi usb 2.0 host usb phy diseqc? eeprom
STI5189 introduction doc id 15458 rev 3 7/9 figure 2. mpeg2 dual tuner, hybrid/dvr satellite stb with hdd figure 3. mpeg2 broadcast satellite stb (common interface zapper) STI5189 stv0289 flash ddram vcr rs232 ir tx/rx smartcards satellite tuner satellite tuner sdr or usb phy hdd usb 2.0 host splitter ethernet phy ethernet rj45 lfbga 15 x 15 hs-spi diseqc? eeprom STI5189 flash ddram vcr rs232 ir tx/rx smartcards satellite sdr or bga 23 x 23 iq in hs-spi dvb-ci usb phy hdd usb 2.0 host nand emi tuner eeprom diseqc?
ordering information STI5189 8/9 doc id 15458 rev 3 2 ordering information table 2. ordering information 3 revision history order code packaging description STI5189zbb lfbga 15 x 15 mm development version. STI5189zyb pbga 23 x 23 mm development version, all options. table 3. document revision history date revision changes 05-mar-2009 1 initial release 10-mar-2009 2 banner removed, no change in document contents. 30-jul-2009 3 section 1.2: package options updated. corporate template 3.1 applied. new cover graphic applied. table 1 amended. tsmf reference removed. if input changed to iq. features/benefits table added to page 2.
STI5189 doc id 15458 rev 3 9/9 please read carefully: i nformation in this document is provided solely in connection with st products. stmicroelectronics nv and its subsidiaries (?st? ) reserve th e r ight to make changes, corrections, modifications or improvements, to this document, and the products and services described her ein at an y t ime, without notice. a ll st products are sold pursuant to st?s terms and conditions of sale. p urchasers are solely responsible for the choice, selection and use of the st products and services described herein, and st ass umes n o l iability whatsoever relating to the choice, selection or use of the st products and services described herein. n o license, express or implied, by estoppel or otherwise, to any intellectual property rights is granted under this document. if any part of th is d ocument refers to any third party products or services it shall not be deemed a license grant by st for the use of such third p arty produc ts o r services, or any intellectual property contained therein or considered as a warranty covering the use in any manner whatsoeve r of suc h t hird party products or services or any intellectual property contained therein. u nless otherwise set forth in st?s terms and conditions of sale st disclaims any express or implie d w arranty with respect to the use and/or sale of st products including without limitation implie d w arranties of merchantability, fitness for a particular purpose (and their equivalents under the law s o f any jurisdiction), or infringement of any patent, copyright or other intellectual property right. u nless expressly approved in writing by an authorized st representative, st products are no t r ecommended, authorized or warranted for use in military, air craft, space, life saving, or life sustainin g a pplications, nor in products or systems where failure or malfunction may result in personal injur y, d eath, or severe property or environmental damage. st products which are not specified as "automotiv e g rade" may only be used in automotive applications at user?s own risk. r esale of st products with provisions different from the statement s and/or technical features set forth in this document shall i mmediately vo id a ny warranty granted by st for the st product or service described herein and shall not create or extend in any manner whatsoeve r, an y l iability of st. st and the st logo are trademarks or register ed trademarks of st in various countries. information in this document supersedes and replaces all information previously supplied. the st logo is a registered trademark of stmicroelectronics. all other names are the property of their respective owners. ? 2009 stmicroelectronics - all rights reserved stmicroelectronics group of companies australia - belgium - brazil - canada - china - czech republic - finland - france - germany - hong kong - india - israel - ital y - japan - malaysia - malta - morocco - philippines - singapore - spain - sweden - switzerland - united kingdom - united states of america www.st.com
|
